[1]郭仁宁,任常在,冯新伟.变频回热式热泵烤烟房的研究[J].黑龙江农业科学,2012,(03):139-142.
　GUO Ren-ning,REN Chang-zai,FENG Xin-wei.Research on Frequency Conversion Regenerative Heat Pump Cured Tobacco Room[J].HEILONGJIANG AGRICULTURAL SCIENCES,2012,(03):139-142.
点击复制

变频回热式热泵烤烟房的研究

《黑龙江农业科学》[ISSN:1002-2767/CN:23-1204/S] 卷: 期数: 2012年03 页码: 139-142 栏目: 出版日期: 2012-03-01
Title:
Research on Frequency Conversion Regenerative Heat Pump Cured Tobacco Room
文章编号:
1002-2767（2012）03-0139-04
作者:
郭仁宁1; 任常在1; 冯新伟2
1.辽宁工程技术大学 机械工程学院，辽宁 阜新 123000；
2.沈阳农业大学 高等职业技术学院，辽宁 沈阳 110000
Author(s):
GUO Ren-ning1; REN Chang-zai1; FENG Xin-wei2
1.Mechanical Engineering College of Liaoning Technical University，Fuxin,Liaoning 123000;
2.Advanced Vocational Technical College of Shenyang Agricultural University，Shenyang,Liaoning 110000
关键词:
烤烟; 变频; 回热; 热泵; 节能
Keywords:
cured tobacco; frequency conversion; heat recovery; heat pump; energy saving
分类号:
S210.3；S572
文献标志码:
A
摘要:
由于传统烤烟容易出现青烟、挂灰、黑糟、阴筋和烤红等影响烤烟质量的问题，目前我国烤烟房主要以立式炉或蜂窝煤火炉作热源，地窖和天窗作排气除湿口，这种方法能源消耗大，效率低。为了解决这些问题，采用变频回热式热泵系统作热源供给烤烟房热量，通过改变压缩机的转速，使压缩机的热负荷的变化与热泵烤房内的热量变化达到最佳匹配，同时再利用回热器使烤烟房排出湿空气的热量来加热蒸发器的干空气以提高热泵干燥系统的去湿能力。变频回热热泵在满足相同的热负荷的情况下，所需要付出的功减小，所以变频回热泵具有省电和性能系数高等优点，具有广阔的发展前景。
Abstract:
Because of the problems of traditional cured tobacco that green tobacco,ash,black bad,cloudy muscle,roasted red affecting the quality of cured tobacco,the present heat sources of cured tobacco room mainly were vertical stove or honeycomb coal stove,exhaust and dehumidification were the cellar and skylight,this method was large energy consumption and low efficiency.In order to solve the above problems,heat source was frequency conversion regenerative heat pump.By changing the speed of the compressor,the compressor heat flux and heat change of heat pump room achieved the best match.Meanwhile forced the heat recovery，the air coming from drying room was cooled before entering the evaporator and the air from the evaporator was heated by heat recovery exchanger,the drying ability of the heat pump drying system was increased.Frequency conversion heat pump to meet the same thermal load cases，the power required could be reduced.Therefore，the frequency conversion heat pump had the advantages of energy saving,high coefficient of performance and had broad prospects for development.

参考文献/References:

[1] 孙培和，王先伟，王法懿，等 . 高温热泵烟叶烤房的研究与应用 [J]. 现代农业科技， 2010(1):252 - 256.

[2]王晓路.航天器变频回热热泵系统研究[D].南京:南京理工大学，2010.

[3]杜垲，张建成.分离式热管回热器用于热泵干燥系统传热分析[J].中国电机工程学报，2001,19(4)：429-433.

[4]希普.热泵[M].张在明,译.北京：化学工业出版社，1984.

[5]宫长荣，周义和，杨焕文.烤烟三段式烘烤导论[M].北京：科学出版社，2006.

[6]史宏志，刘国顺.烟草香味学[M].北京：中国农业出版社,1988.


相似文献/References:

[1]杨通隆,王彩燕.两个烤烟品种（系）在天柱烟区的生产试验[J].黑龙江农业科学,2014,(11):8.
　YANG Tong-long,WANG Cai-yan.Production Test of Two Flue-cured Tobacco Varieties(Lines)in Tianzhu Tobacco Growing Areas[J].HEILONGJIANG AGRICULTURAL SCIENCES,2014,(03):8.
[2]周丽影,郑国栋,徐爽,等.烤烟叶片成熟过程中光合生理特性的变化[J].黑龙江农业科学,2014,(04):40.
　ZHOU Li ying,ZHENG Guo dong,XU Shuang,et al.Change of Leaf Photosynthesis Physiological Characters in Flue cured Tobacco During the Mature Stage[J].HEILONGJIANG AGRICULTURAL SCIENCES,2014,(03):40.
[3]董洪涛,陈兴,焦玉生,等.木耳菌糠有机肥对烤烟干物质的影响[J].黑龙江农业科学,2014,(04):51.
　DONG Hong tao,CHEN Xing,JIAO Yu sheng,et al.Effect of Agaric Bran Organic Fertilizer on Dry Matters of Fluecured Tobacco[J].HEILONGJIANG AGRICULTURAL SCIENCES,2014,(03):51.
[4]田艳洪,赵晓锋,刘文志,等.腐殖酸对连作烟田土壤性状及烟株生长的影响[J].黑龙江农业科学,2012,(03):58.
　TIAN Yan-hong,ZHAO Xiao-feng,LIU Wen-zhi,et al.Effect of Humic Acid on Soil Characteristics and Plant Growth of Continuous Cropping Tobacco Field[J].HEILONGJIANG AGRICULTURAL SCIENCES,2012,(03):58.
[5]武德里,封洁琼,彭静,等.不同灌溉方式对烤烟产量和化学品质及水分利用率的影响[J].黑龙江农业科学,2013,(04):20.
　WU De-li,FENG Jie-qiong,PENG Jing,et al.Effects of Different Irrigation Method on the Yield,Chemical Properties and Water Use Efficiency of Flue-Cured Tobacco[J].HEILONGJIANG AGRICULTURAL SCIENCES,2013,(03):20.
[6]马献发,焦玉生,张继舟,等.基于图像分析技术的烤烟叶片含氮量诊断模型[J].黑龙江农业科学,2011,(11):23.
　MA Xian-fa,JIAO Yu-sheng,ZHANG Ji-zhou,et al.Diagnostic Model of Nitrogen Content in Tobacco Leaf by Image Analysis[J].HEILONGJIANG AGRICULTURAL SCIENCES,2011,(03):23.
[7]元 野,王光华,赵光伟,等.不同种植制度下烤烟根际土壤微生物群落结构的变化[J].黑龙江农业科学,2011,(11):26.
　YUAN Ye,WANG Guang-hua,ZHAO Guang-wei,et al.Changes of Microbial Community Structure on Flue-cured Tobacco Soil Rhizosphere in Different Cropping Systems[J].HEILONGJIANG AGRICULTURAL SCIENCES,2011,(03):26.
[8]梁美萍,王 岩,申艳霞,等.烤烟新品种辽烟17的选育及特征特性[J].黑龙江农业科学,2010,(01):130.
　[J].HEILONGJIANG AGRICULTURAL SCIENCES,2010,(03):130.
[9]杨春元,刘正华,李余湘,等.不同环剥时期对烤烟产质量的影响[J].黑龙江农业科学,2011,(12):22.
　YANG Chun-yuan,LIU Zheng-hua,LI Yu-xiang,et al.Effects of Girdling at Different Stages on Quality and Yield of Flue-cured Tobacco[J].HEILONGJIANG AGRICULTURAL SCIENCES,2011,(03):22.
[10]崔健国,金丹丹,王晓也,等.不同施氮量对烤烟磷积累以及磷肥利用率的影响[J].黑龙江农业科学,2010,(11):35.
　CUI Jian-guo,JIN Dan-dan,WANG Xiao-ye,et al.Study of Different Nitrogen for Phosphorus Accumulation ofFlue-cured Tobacco and Utilization of Phosphorus[J].HEILONGJIANG AGRICULTURAL SCIENCES,2010,(03):35.

备注/Memo

第一作者简介：郭仁宁（1956-），男，辽宁省阜新市人，硕士，教授，硕士研究生导师，从事流体机械及热能工程研究。E-mail:guorenning123@163.com。

更新日期/Last Update: 2014-10-26